OPEN ACCESS

Articles online

Laboratory Evaluation of a Manure Additive for Mitigating Gas and Odor Releases from Layer Hen Manure

Category: Control Techniques and Strategy

Accepted Manuscripts
DOI: 10.4209/aaqr.2016.07.0327
PDF | RIS | BibTeX

Ji-Qin Ni , Albert J. Heber, Teng T. Lim, Sam M. Hanni, Claude A. Diehl

  • Department of Agricultural and Biological Engineering, Purdue University, West Lafayette, Indiana 47907, USA

Highlights

Reported evaluations of commercial additives for manure treatment have mixed results.
Additive Eco-Cure on layer hen manure was evaluated in controlled lab conditions.
The results could not prove reductions of gases and odors released from manure.


Abstract

Manure additives are widely used to mitigate gas and odor emissions from manure or improve manure properties. However, the reported effectiveness of some manure additive products has been mixed and most of the studies on poultry manure have been on chemical additives. A laboratory study was conducted to evaluate an enzyme-based commercial manure additive for its potential reductions of ammonia (NH3), carbon dioxide (CO2), hydrogen sulfide (H2S), and odor releases from layer hen manure. Eight 122-cm tall and 38-cm diameter reactors, four treated with the additive and four control, were studied for 38 days with manure from commercial layer hen houses. The reactors were initially filled with 66-cm height manure followed by weekly additions of 5 cm each. Ventilation air was supplied to the reactor headspace to simulate winter ventilation rates in layer hen houses. Concentrations of NH3, CO2, and H2S in the reactor exhaust air were measured with gas analyzers for 10 min, six times daily. Odor intensity was assessed by a trained odor panel. Open-headspace tests were also conducted to corroborate the observations in the reactor study. Study results showed that the average 4-reactor group mean release rates ± standard deviations of NH3 were 17.3 ± 15.1 and 19.9 ± 13.4 µg s–1 from the control and treated groups, respectively. Those of CO2 were 1086 ± 157 µg s–1 from the control and 1146 ± 237 µg s–1 from the treated groups. Release of H2S from the reactors could not be detected. The odor intensities were 3.5 ± 0.3 and 3.4 ± 0.3 before and after the additive spray, respectively. Application of the additive onto the manure did not demonstrate effect on the releases of NH3 (P > 0.41), CO2 (P > 0.21), and odor (P > 0.71) from the manure.

Keywords

Agricultural wastes Emission mitigation Manure treatment Poultry manure Waste management


Related Article

High Selectivity of Visible-Light-Driven La-doped TiO2 Photocatalysts for NO Removal

Yu Huang, Jun-Ji Cao, Fei Kang, Sheng-Jie You, Chia-Wei Chang, Ya-Fen Wang
Accepted Manuscripts
DOI: 10.4209/aaqr.2017.08.0282
PDF

Study of Flow Patterns in Two-Stage Mode of Moving Granular Bed Filter

Chia-Wei Chang, Shu-San Hsiau , Yi-Shun Chen, Yan-Pin Chyou, Jiri Smid
Accepted Manuscripts
DOI: 10.4209/aaqr.2016.12.0588
PDF
;