Articles online

Selective Catalytic Reduction of NO over Cu–Mn/OMC Catalysts: Effect of Preparation Method

Category: Air Pollution Modeling

Volume: 17 | Issue: 1 | Pages: 302-313
DOI: 10.4209/aaqr.2015.12.0693
PDF | RIS | BibTeX

Xinning Yu, Feifei Cao, Xinbo Zhu, Xuecheng Zhu, Xiang Gao , Zhongyang Luo, Kefa Cen

  • State Key Laboratory of Clean Energy Utilization, Zhejiang University, Hangzhou 310027, China


Cu-Mn/OMC catalysts were prepared by different methods for the SCR of NO.
Cu-Mn/OMC(S) exhibits the highest NO conversion and N2 selectivity.
Preparation methods affect the structural and surface properties of Cu-Mn/OMC.
Active phases show small size and homogenous distribution on Cu-Mn/OMC(S).


Ordered mesoporous carbon (OMC) was used as support for CuOx and MnOx, and the effects of preparation method on selective catalytic reduction (SCR) of NO with NH3 were investigated. The Cu–Mn/OMC prepared by solvent evaporation-induced self-assembly method, named as self-assembly synthesis (S), exhibited higher NO conversion and N2 selectivity than the catalyst prepared by ultrasound-assisted impregnation (I) or mechanical mixing (M). The structural and surface properties of catalysts were characterized by various techniques. XRD and TEM results showed good dispersion of active phases on Cu–Mn/OMC(S). XPS analysis suggested that the surface of Cu–Mn/OMC(S) had the maximum amount of O–C=O groups and chemisorbed O. The strongest acidity and largest amount of oxidative species were further illustrated by NH3-TPD and H2-TPR profiles, which were consistent with the XPS results. Accordingly, these favorable properties may be the main reasons for the outstanding performance of Cu–Mn/OMC(S) in NH3-SCR reaction. Thus, self-assembly synthesis can be considered an effective method for the preparation of OMC–supported catalysts.


NH3-SCR NO removal Cu-Mn/OMC Preparation method

Related Article

Improvement of the Real-time PM2.5 Forecast over the Beijing-Tianjin-Hebei Region using an Optimal Interpolation Data Assimilation Method

Haitao Zheng, Jianguo Liu , Xiao Tang, Zifa Wang , Huangjian Wu, Pingzhong Yan, Wei Wang
Accepted Manuscripts
DOI: 10.4209/aaqr.2017.11.0522

Determining VOCs Reactivity for Ozone Forming Potential in the Megacity of São Paulo

Débora Souza Alvim , Luciana Vanni Gatti, Sergio Machado Corrêa, Júlio Barboza Chiquetto, Guaciara Macedo Santos, Carlos de Souza Rossatti, Angélica Pretto, José Roberto Rozante, Silvio Nilo Figueroa, Jayant Pendharkar, Paulo Nobre
Accepted Manuscripts
DOI: 10.4209/aaqr.2017.10.0361