About AAQR

Aims and Scope

Articles online
For contributors
Call for Papers
Guideline for the
Special Issue Proposal
Subscription
Information

Advertising

Contact Us
 
Search for  in   Search  Advanced search  

 

Volume 5, No. 2, December 2005, Pages 211-224 PDF(263 KB)  
doi: null   

Direct Conversion of Methane into Methanol and Formaldehyde in an RF Plasma Environment II: Effects of Experimental Parameters

Ya-Fen Wanga, Cheng-Hsien Tsaib, Minliang Shihc, Lien-Te Hsiehd, Wen-Ching Changc

a Department of Bioenvironmental Engineering, Chung Yuan Christian University, No. 200, Chung Pei Road, Chung-Li 320, Taiwan
b Department of Chemical Engineering, National Kaohsiung University of Applied Sciences, No. 415, Chien Kung Road, Kaohsiung 807, Taiwan
c Department of Environmental Engineering and Science, Chia-Nan University of Pharmacy and Science, No. 60, Sec. 1, Erh-Jen Road, Tainan 717, Taiwan
d Department of Environmental Engineering and Science National Pingtung University of Science and Technology, 1Hseuh Fu Rd., Nei Pu Hsiang, Ping Tung, 912, Taiwan

 

Abstract

 

To provide information on the conversion of methane in a non-catalyzed radio-frequency (RF) plasma system into valuable chemicals, such as HCHO, CH3OH, C2H6, C2H4 and C2H2, an experiment was conducted to convert methane directly into methanol and formaldehyde. The effects of experimental parameters—specific energy (power or flow variation) and CH4 and O2 feeding concentrations—were examined. Carbon-based by-products generated in a CH4/O2/Ar RF plasma system included CO, CO2, HCHO, CH3OH, C2H6, C2H4 and C2H2. The methane conversion ratio increased as the feeding concentration of O2 and the specific energy was increased, but decreased with feeding of CH4. Increasing power in the RF plasma system did not favor the partial oxidation of CH4 toward CH3OH and HCHO, but did favor the production of C2-hydrocarbons (C2H6, C2H4 and C2H2), CO, and CO2. The CH4 feeding concentration of under 15% or an O2 content of under 10% favored the formation of CH3OH and HCHO. CO concentration decreased as the feeding concentration of CH4 increased, and increased as the feeding concentration of O2 increased. The yield of CH3OH was less than 1%. No carbon black or deposition was observed. Further research will seek to increase the yield of CH3OH and HCHO by adding catalysts to the system.

 

 

Keywords: Methane; Methanol; Formaldehyde; Radio-frequency plasma.

 

 

Copyright © 2009-2014 AAQR All right reserved.