About AAQR

Aims and Scope

Articles online
For contributors
Call for Papers
Guideline for the
Special Issue Proposal
Subscription
Information

Advertising

Contact Us
 
Search for  in   Search  Advanced search  

 

Volume 17, No. 2, February 2017, Pages 636-643 PDF(355 KB)  
doi: 10.4209/aaqr.2016.05.0200   

PM2.5 Emission Reduction by Technical Improvement in a Typical Coal-Fired Power Plant in China

Zizhen Ma1, Zhen Li1, Jingkun Jiang1, Jianguo Deng1, Yu Zhao2, Shuxiao Wang1, Lei Duan1

1 State Key Laboratory of Environmental Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China
2 School of the Environment, Nanjing University, Nanjing 210023, China

 

Highlights
  • Advanced combustion technology decreases PM2.5 emission factor by 20%.
  • PM2.5 emission was reduced for the application of cold-side ESP.
  • Some air pollution control devices may increase emission of SO42– and Ca2+.

Abstract

 

To investigate PM2.5 reduction by technical improvement in typical Chinese coal-fired power plants, two units built in different time with different particulate matter (PM) control technologies but with the same coal-fired boiler type were selected to characterize the concentrations of PM2.5 generated and emitted from coal-fired power plants. We found that significant benefit of PM2.5 emission reduction was achieved by technological improvement. Due to the increase in the installed capacity and the application of low NOx burner alone, PM2.5 emission factor without adopting other air pollution control devices decreased from 0.153 kg t–1 (the 100 MW unit) to 0.123 kg t–1 (the 300 MW unit). With the help of an improved electrostatic precipitator (ESP) of which removal efficiency increased from 76.4% to 97.5%, PM2.5 emission factor further decreased from 0.014 kg t–1 (the unit with a normal ESP) to 0.003 kg t–1 (the unit with a cold-side ESP and a wet flue gas desulphurization (WFGD)). However, the application of flue gas denitrification and desulfurization devices may alter PM2.5 compositions and their emissions. For instance, the installation of a WFGD was found to largely increase the emissions of water-soluble ions in PM2.5 (e.g., SO42–, Ca2+, and NH4+).

 

 

Keywords: PM2.5; Emission factor; Coal-fired power plant; Water-soluble inorganic ion; Wet flue gas desulphurization (WFGD).

 

 

Copyright © 2009-2014 AAQR All right reserved.