Volume 16, No. 9, September 2016, Pages 2198-2207 PDF(1.33 MB)
Control of Bioaerosols in Indoor Environment by Filter Coated with Nanosilicate Platelet Supported Silver Nanohybrid (AgNPs/NSP)
Jiung-Wen Chen1, Grace Whei-May Lee1, Kai-Jie Chen1, Shin-Hao Yang2
1 Graduate Institute of Environmental Engineering, National Taiwan University, Taipei 10617, Taiwan
2 Department of Nutritional Science, Toko University, Chiayi County 61363, Taiwan
- Development of antimicrobial air filter using AgNPs/NSP with low toxicity.
- Evaluation of antimicrobial effect by filtration test and HVAC simulation system.
- Comparison of antimicrobial effect between two different relative humidity.
Currently silver nanoparticles (AgNP)-modified filter are widely used to inactivate airborne microbes in indoor environment. However, AgNP is extremely small and thus will penetrate cells membranes to cause cytotoxicity. AgNPs/NSP has been proven to be less cytotoxic to human body. In this study, it was the first time that AgNPs/NSP was used to develop a new antimicrobial air filter with low cytotoxicity. The AgNPs/NSP filter was made by dip-coating of filter with AgNPs/NSP and acrylic resin solution and three different amount of silver on filter were obtained including 12.6, 31.5 and 63 ppm. The filtration efficiency and the antimicrobial activity of AgNP/NSP filter were evaluated by bioaerosols including Escherichia coli and Candida famata in testing chamber and HVAC simulation system under 30% and 70% relative humidity (RH). The results showed that filtration efficiency of AgNPs/NSP-modified filter increased by about 13 to 20% compared to unmodified filter for E. coli but remained almost the same for C. famata. The antimicrobial efficiency of AgNPs/NSP modified filter of 63 ppm was 95.1% for E. coli at RH of 30%. In addition, 91% of antimicrobial efficiency for C. famata was found at RH of 70%. On the other hand, the antimicrobial efficiency of yeast for AgNPs/NSP-modified filter was 97.8% and 86.4% for RH of 30% and 70% respectively when yeast just started to contact with filter in HVAC system. The results suggest that AgNP/NSP-modified air filter can effectively inactivate microorganisms retained on. Therefore, emission of bioaerosols from air filter can be avoided in order to improve the air cleaning technology in indoor environment.
Silver nanoparticles; Filtration; Antimicrobial activity; Airborne microbes; Antimicrobial filter.